Jonn fitted a new ignition switch to our 1984 Morgan 4/4. As the wire colours on the replacement switch differed slightly from the original, he first identified the function of each wire. He then removed the existing multi-plug connector and soldered on new bullet terminals to suit. These were connected to the car’s wiring, and […]
Jonn fitted a new manifold-to-downpipe gasket on our 1984 Morgan 4/4, ensuring it was properly sealed and securely fastened. A new starter motor was sourced, but it proved to be the incorrect type.
Jonn investigated an exhaust blow on our 1984 Morgan 4/4, traced to the joint between the manifold and downpipe. He applied heat to release and remove the downpipe nuts and studs, then cleaned both mating surfaces as thoroughly as possible given the limited access. The starter motor was removed in preparation for fitting a new […]
Jonn carefully applied heat to the steering wheel of our Morgan 4/4 in order to remove it. Once removed, he turned the wheel to the left and refitted it to correct the alignment. An initial test was carried out around the yard, followed by a run up the road, both confirming that the steering wheel […]
A new elastic seat web base has been fitted to our Morgan. The old one had completely perished and collapsed, so a new one was needed.
Jonn hoovered out the interior of our 1984 Morgan 4/4 before refitting the driver’s seat. To ensure the seat was securely installed and to distribute the load more evenly, repair washers were fitted beneath the floor. He then removed the gear lever to investigate further issues, during which he found remnants of a broken bush. […]
Pete began work on our 1984 Morgan 4/4 by removing the driver’s seat to investigate a noticeable sag in the seat base. Upon inspection, it was found that the sprung mesh panel spanning the base had torn. Photographs were taken to aid the parts team in sourcing or fabricating a replacement section. The seat was […]
We see a lot cars come through our workshops on a weekly if not daily basis here at Bridge Classic Cars. Some scheduled for work, and others urgent repairs for their owners, much like this week. A handful of classics and a Rover 75 Estate which we need to get back on the road for […]