Classic car technician Alan has been doing more work on our 1956 Jensen 541. After repairing the roof and bonnet of this classic car, Alan turned his attention to the doors. He removed the door skins from the frames so he could apply epoxy primer to both sides. Epoxy primer was also applied to the […]
Classic car technician Alan has once again been repairing and replacing parts of the fibreglass body of our 1956 Jensen 541. He ground back the cracks in the bonnet before covering it in a new sheet of fibreglass. In addition to this, Alan also reinforced all the bonnet supports as they were weak and loose. […]
Our classic car technician, Clinton, has been making parts that will ultimately go on to be fitted into one of our ongoing Jensen projects. The bonnet strips he made can be seen in the photos below.
Not only has classic car technician Alan been busy repairing the fibreglass roof of our 1956 Jensen 541, but he has also been repairing a hole in the bonnet too. He repaired the inside first by attaching some meshing which would provide more support for the repair. Once the inside of the hole was sealed, […]
The history of the Jensen 541 is an interesting story that goes all the way back to 1953. Before the release of the 541, Jensen Motors predominantly used aluminium to make the bodywork of their Interceptors. Interestingly, the boot lid of the Jensen Interceptor though was made from fibreglass. Fibreglass was not commonly used in […]
The Jensen 541 was a car produced by Jensen Motors. Each one of these cars has an individual story to tell, but the story of the Jensen 541, in general, is one that many car enthusiasts should be keen to hear. If you want to know more about these truly iconic classic cars, then this […]
Our 1956 Jensen 541 has been the target of our classic car technician’s attention as of late. Over the past few days, the bonnet has been repaired so that it now lines up beautifully with the doors, some body panels have been gapped and aligned, and a new layer of fibreglass has been added to […]
There are quite a few Jensens being restored in our workshop at the moment (7 at the last count including 541s, 541Rs, and an Interceptor MK3). As there is a lot of work to get done on these classic cars, it’s usually very beneficial to bulk produce some of the smaller parts so they are […]
In the workshops right now, we have 6x Jensen 541’s in various states of repair or restoration. We have 3x Jensen 541’s and 3x Jensen 541R’s. Sometimes, when fabricating parts it is much more time and cost effective for Clinton to produce more than one item. In this instance, Clinton has been working on re-producing […]
Mauro spent the afternoon in the booth preparing parts for a number of our Jensen projects. Blasted parts have been prepared and painted and will now be wrapped up ready for reassembly.
The 1956 Jensen 541 has been moved from the Bridge Classic Cars workshop to begin its bodywork journey. As part of its restoration, the team will go through every panel and gap to make sure everything is absolutely perfect before it is painted. Before then, our restoration workshop have worked on every aspect of the […]
Local artist Paul Seymour has sent us in this beautiful watercolour painting of our 1959 Jensen 541R that he sketched at our stand at this years Helmingham Hall Classic & Sports Car Festival. We brought along the 541R which is in the early stages of its restoration with us. We’ve even got some photos of […]
The 1956 Jensen 541 has been worked on in the Bridge Classic Workshop at our Suffolk HQ to have several parts on the car adjusted and refined. Our technician Rob first fabricated the new handbrake bracket/mount. This was bent up and shaped before the original piece was cut off the frame and the new piece […]
The restoration workshop at the Bridge Classic Cars HQ have been working on getting the various mounts, brackets and hinges into place on the 1956 Jensen 541. To begin with, our technician Rob made new arch filler panels which bridge the gap between the frame and the fibreglass body, blending the two together for strength […]
The workshop at Bridge Classic Cars have been making good progress on the 1956 Jensen 541 at our Suffolk HQ for restoration. To begin with, our technician Rob, has made and welded in the new seat mounts into the specially made chassis of the classic GT car and ground them smooth to blend them into […]
The Bridge Classic Cars workshop have made great progress on the 1956 Jensen 541. Our technician, Rob, has been working on the front end of the classic Jensen. To begin with, he fully welded in the suspension towers onto the new chassis. This is a crucial stage as it also acts as a tie-in for […]
The restoration workshop at the Bridge Classic Cars Suffolk HQ have been working on the 1956 Jensen 541. This time, our technician Rob has been finishing up adjusting and finish welding the door supports for the car. With all of the supports and brackets perfectly in place to get the door gaps and alignment right, […]
The workshop at Bridge Classic Cars are in the process of getting the doors aligned and adjusted to the body of the 1956 Jensen 541. To begin with, our technician Rob welded in the A-pillar bracing fully before offering up the door frame. Once in place, he could then begin to check throughout the opening […]
The 1956 Jensen 541 has had some new parts and pieces fitted during its build-up in the Bridge Classic Cars workshop at our Suffolk HQ.# The team have test fit a new door skin to the frame to make sure everything lines up and fits as it should before then fitting the door to the […]
The workshop team have made new strengthening brackets for the roof and A-Pillar of the 1956 Jensen 541 which is in for restoration. Rob, one of our restoration technicians, has handmade the brackets which are done specifically for each area of the car to tie the various pieces together. After shaping and test fitting, the […]
The restoration workshop at the Bridge Classic Cars Suffolk HQ have bolted the roof and rear bodywork to the new frame of the 1956 Jensen 541 for the first time! After making the careful and delicate adjustments to the framework and chassis of the classic Jensen, the team could begin the process of mocking up […]
The workshop team at Bridge Classic Cars have worked on the fine alterations to the framework of the 1956 Jensen 541 in for restoration at our Suffolk HQ. The team have test fit the rear fibreglass clamshell and with that, they could make small changes to the framework which gives the body panels structure and […]
The workshop team at Bridge Classic Cars has been making the fine adjustments to the inner framework of the 1956 Jensen 541 in with us at our Suffolk HQ for restoration. Rob, one of our technicians, has carefully had the fibreglass body panels placed around the framework and on top of the chassis of the […]
The workshop at Bridge Classic Cars is working on the chassis of the 1956 Jensen 541 currently in for its full restoration by us here in Suffolk. Recently the team have been working on adjusting and refining the brand new chassis for the classic GT car. Now with the majority of the reinforcements and adjustments […]
The workshop at Bridge Classic Cars have been working on the fine adjustments to the chassis of the 1956 Jensen 541 in for restoration. The team are beginning to weld in the necessary braces and panels as the sides and roof structure begin to be put onto the brand-new frame. For a job such as […]
The Bridge Classic Cars paint and body team have been working on perfecting the wheel wells of the 1956 Jensen 541. After the team had finished with the careful resin and fibreglass filler work, the team brought them into our in-house paint booth/oven to have their first coats of primer. The team have carefully blended […]
The 1956 Jensen 541 chassis which arrived back at the Bridge Classic Cars HQ recently has been moved into our restoration workshops for the team to begin work on the brand-new frame. At this stage, Rob is preparing the blank bulkhead to be fitted onto the car in preparation for its left-hand drive conversion. Carefully […]
The body team at Bridge Classic Cars have been performing some fibreglass repairs on the boot lid of the 1956 Jensen 541 in with us for restoration. Mauro has carefully reglassed certain areas of the bootlid to strengthen key places as well as refit the stripped-back boot latch. All of these were then built up […]
The trim team at Bridge Classic Cars have been continuing work on the roof supports of the 1956 Jensen 541. Previously, our trimmer Brian handmade the roof supports for the rear window of the classic Jensen which have been specifically profiled to fit the recess perfectly. With the pieces now test fit, the team could […]